Item Affected: VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

Date Announced: 06/22/2017

Description of Recall: VEHICLE DESCRIPTION: SCHOOL BUSES EQUIPPED WITH ROSCO CROSS OVER MIRRORS. THE POSITION OF THE DRIVER'S REAR VIEW MIRROR DOES NOT ALLOW COMPLETE VISIBILITY OF PEDESTRIANS AS REQUIRED UNDER FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 111, "REARVIEW MIRRORS."

Conequence: A PEDESTRIAN COULD BE INJURED OR KILLED IF THE DRIVER OF THE SCHOOL BUS CANNOT SEE THEM.

Action Need To Fix It: AMTRAN WILL NOTIFY OWNERS WITH INSTRUCTIONS TO REPOSITION THE DRIVER'S REAR VIEW MIRROR UP 3 1/8 INCHES. OWNER NOTIFICATION BEGAN JUNE 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 501-505-2190.

Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION=S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Item Affected: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:BLOWER

Date Announced: 06/22/2017

Description of Recall: VEHICLE DESCRIPTION: CERTAIN SCHOOL AND TRANSIT BUSES WERE BUILT WITH A POOR QUALITY HEATER/DEFROSTER BLOWER SWITCH. IN SOME CASES THIS HAS CAUSED THE MELTING OF THE HEATER HARNESS CONNECTOR AT THE SWITCH TERMINALS OR THE HIGH-SPEED WIRE INSULATION AT THE CONNECTOR. ALSO, SOME OF THE UNITS HAD IMPROPER CIRCUIT PROTECTION SIZE INSTALLED IN THE HEATER DEFROSTER CIRCUIT.

Conequence: IF AN OPERATOR DETECTS SMOKE OR THE SMELL OF MELTING WIRE INSULATION FROM THE BLOWER CONTROL PANEL, THE OPERATION OF THE HEATER/DEFROSTER AT HIGH SPEED SHOULD BE DISCONTINUED UNTIL THE REPAIR IS MADE.

Action Need To Fix It: OWNERS WILL BE PROVIDED WITH INSTRUCTIONS AND PARTS TO REPLACE THE SWITCH AND SWITCH HARNESS WITH A NEW SWITCH, SWITCH HARNESS, RELAY AND RELAY HARNESS. FOR THE RE UNITS BUILT PRIOR TO JANUARY 1, 1999, THE KIT WILL ALSO INCLUDE A 20-AMPERE MANUAL CIRCUIT BREAKER. OWNER NOTIFICATION BEGAN DECEMBER 15, 2001. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 800-843-5615.

Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION=S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Item Affected: ELECTRICAL SYSTEM:WIRING

Date Announced: 06/22/2017

Description of Recall: VEHICLE DESCRIPTION: CERTAIN BUSES WERE BUILT WITH A WIRING DIAGRAM DECAL THAT SHOWS THE CIRCUIT PROTECTION SIZE OF 30 AMPERES INSTEAD OF 20 AMPERES FOR THE HEATER SUPPLY CIRCUITS.

Conequence: ELECTRICAL COMPONENT FAILURE WITHOUT THE CORRECT PROTECTION IN SOME CASES CAN CAUSE OVERHEATING OF THE COMPONENT AND/OR FIRE.

Action Need To Fix It: OWNERS WILL BE PROVIDED WITH A STRIP AND INSTALLATION INSTRUCTIONS THAT SHOULD BE PLACED OVER THE INCORRECT INFORMATION ON THE CURRENT DECAL. OWNER NOTIFICATION BEGAN DECEMBER 21, 2001. OWNERS WHO DO NOT RECEIVE THE FREE STRIP AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 1-800-993-7686.

Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Item Affected: ELECTRICAL SYSTEM:WIRING

Date Announced: 06/22/2017

Description of Recall: VEHICLE DESCRIPTION: CERTAIN BUSES WERE BUILT WITH AN IMPROPER CONNECTION OF THE HEATER HARNESS FROM THE HEATER SWITCH TO THE CONNECTOR JUST OUTSIDE THE HEATER UNIT. THE ASSEMBLY LEFT A LOOSE HOT WIRE IN THE HEATER HARNESS WITH AN UNPROTECTED TERMINAL THAT COULD CAUSE A DIRECT SHORT. THIS WIRE IS PROTECTED WITH A 20-AMPERE CIRCUIT PROTECTION, BUT IN A RARE CASE COULD CAUSE A FIRE.

Conequence: ELECTRICAL COMPONENT FAILURE WITHOUT THE CORRECT PROTECTION IN SOME CASES CAN CAUSE OVERHEATING OF THE COMPONENT.

Action Need To Fix It: OWNERS WILL BE PROVIDED WITH INSTRUCTIONS ON HOW TO REPAIR THE DEFECT. THE REPAIR PROCEDURE FOR THIS DEFECT WILL REQUIRE PLACING THE CONNECTORS CORRECTLY IN THE TERMINALS TO THE HIGH-SPEED BLOWER RELAY AND HARNESS CONNECTION AT THE HEATER. OWNER NOTIFICATION BEGAN DECEMBER 18, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 1-800-843-5615.

Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Item Affected: STRUCTURE:BODY:ROOF AND PILLARS

Date Announced: 06/22/2017

Description of Recall: CERTAIN SCHOOL BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." THESE BUSES DO NOT COMPLY WITH THE EMERGENCY EXIT REQUIREMENTS.

Conequence: DURING AN EMERGENCY SITUATION, THIS CONDITION COULD PREVENT PASSENGERS FROM EXITING THE BUS, WHICH COULD CAUSE PERSONAL INJURY OR DEATH.

Action Need To Fix It: DEALERS WILL ADD ONE ROOF EXIT IN THE CENTER OF THE PASSENGER COMPARTMENT. ALL OWNERS HAVE BEEN NOTIFIED AND ARRANGEMENTS MADE TO REMEDY THEIR BUSES.

Notes: IC RECALL NO. 03302. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Item Affected: STRUCTURE:BODY

Date Announced: 06/22/2017

Description of Recall: CE MODEL SCHOOL BUSES WHICH FAIL TO COMPLY TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, SCHOOL BUS BODY JOINT STRENGTH. THE ROOF TOP SHEET MAY BE IMPROPERLY LOCATED, REDUCING THE MATERIAL EDGE DISTANCE AT THE RIVET LINE.

Conequence: IN THE EVENT OF A VEHICLE CRASH, THE JOINT STRENGHT COULD FAIL POSSIBILY RESULTING IN INJURIES TO THE VEHICLE OCCUPANTS.

Action Need To Fix It: IC WILL NOTIFY ITS CUSTOMERS AND WILL PROVIDE INSPECTION AND REPAIR INSTRUCTION. THE RECALL BEGAN ON JANUARY 25, 2005. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC CUSTOMER SERVICE AT (WE DO NOT YET HAVE A TELEPHONE NUMBER FOR THIS CAMPAIGN.)

Notes: IC RECALL NO. 03305. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Item Affected: STRUCTURE:BODY

Date Announced: 06/22/2017

Description of Recall: CERTAIN FE MODEL SCHOOL BUSES MANUFACTURED FROM OCTOBER 14, 1991, AND MARCH 4, 2003. A GAP BETWEEN THE MODESTY PANEL AND THE WHEEL WELL LOCATED BEHIND THE DRIVER'S SEAT CAN BE CREATED IF THE PANEL IS BENT OUT OF POSITION. UNDER THE PANEL, THE EDGES ARE SHARP AND JAGGED.

Conequence: SHOULD SOMEONE REACH UNDER THE PANEL, THEY COULD CUT THIER HANDS, FINGERS, OR TOES ON THE JAGGED EDGES.

Action Need To Fix It: IC WILL NOTIFY ITS CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO BEGIN JANUARY 20, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC CORPORATION COMPLIANCE DEPARTMENT TOLL-FREE AT 1-800-843-5615. CUSTOMERS CAN LOCATE THE NEAREST DEALER BY CALLING 1-800-993-7686.

Notes: ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Item Affected: EQUIPMENT ADAPTIVE

Date Announced: 06/22/2017

Description of Recall: CERTAIN MY 2001-2005 AMTRAN/IC CORPORATION CE, FE, AND RE SCHOOL BUSES EQUIPPED WITH SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.

Conequence: IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES.

Action Need To Fix It: SURE-LOK WILL NOTIFY IC'S CUSTOMERS AND REPAIR THE BUSES ON IC'S BEHALF AT NO COST TO THE CUSTOMER. THE RECALL BEGAN AUGUST 16, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SURE-LOK AT 1-908-231-1804.

Notes:

Item Affected: SEATS

Date Announced: 06/22/2017

Description of Recall: CERTAIN FE SCHOOL AND COMMERCIAL BUSES BUILT WITH CE WHITE DRIVER SEATS WITH A PEDESTAL STYLE MOUNT AND MANUFACTURED BETWEEN JANUARY 10, 1992 THROUGH FEBRUARY 24, 2004. THESE PEDESTALS CAN DEVELOP CRACKS RENDERING THE SEAT UNSTABLE.

Conequence: IN THE EVENT OF A VEHICLE CRASH, THE SEAT COULD SEPARATE FROM THE BASE, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.

Action Need To Fix It: IC WILL NOTIFY ITS CUSTOMERS AND REPAIR THE SEAT BY REPLACING THE UPPER PORTION OF THE ASSEMBLY WITH A MORE ROBUST DESIGN. THE RECALL BEGAN JUNE 3, 2005. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC COMPLIANCE DEPARTMENT AT 1-800-843-5615.

Notes: IC PREDICTS PARTS WILL BE AVAILABLE IN THE SECOND WEEK OF MAY 2005. CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Item Affected: SEATS

Date Announced: 06/22/2017

Description of Recall: CERTAIN 1998, 2000-2005 MY CE, FE, AND RE SCHOOL BUSES BUILT WITH ONE OR MORE CE WHITE 30-INCH CHILD RESTRAINT SEATS AND MANUFACTURED BETWEEN MARCH 25, 1998 AND AUGUST 24, 2004. THE SEAT CUSHION RETENTION MAY NOT RETAIN THE SEAT IN ALL CIRCUMSTANCES.

Conequence: IN THE EVENT OF A SUDDEN STOP, THE SEAT CUSHION MAY TIP FORWARD AND MAY BECOME UNATTACHED CAUSING THE PASSENGER TO SLIDE OFF THE SEAT AND/OR BE TRAPPED BY THE SEAT CUSHION. THIS ACTION COULD POSSIBLY RESULT IN PERSONAL INJURY OR DEATH.

Action Need To Fix It: IC CORP WILL NOTIFY ITS CUSTOMERS AND WILL REPAIR THE CUSHION BY ADDING A CLIP TO THE CUSHION TYING IT TO THE SEAT FRAME. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC COMPLIANCE DEPARTMENT AT 1-800-843-5615.

Notes: ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).